Product ID:9616, NITRIC ACID
MSDS Date:05/01/1989
FSC:6810
NIIN:00N028267
MSDS Number: BPZFG

J.T.BAKER CHEMICAL CO

222 RED SCHOOL LANE
PHILLPSBURG, NJ 08865
US

Emergency Phone: (201) 859-2151/800-424-9300(CHEMTR)

Info Phone: 800-JTBAKER

Cage: DO870

MALLINCKRODT BAKER, INC.

PHILLIPSBURG, NJ 08865 US

Telephone: 800-582-2537

Cage: 70829

NITRIC ACID

CAS: 7697-37-2

RTECS: QU5775000

Fraction By Weight: 65-71%

OSHA PEL 2 PPM;4 PPM STEL

ACGIH TLV: 2 PPM;4 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 29-35%

OIL, ETC.) AWAY FROM SPILLED MATERIAL.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL: SEVERE IRRIT/BURNS OF RESP SYS,
COUGHING, DIFFICULT BRTHG, CHEST PAINS, PULMONARY EDEMA, LUNG
INFLAMM, UNCON & MAY BE FATAL. SKIN/EYES: SEV IRRIT/BURNS. INGEST:
NAUSEA, VOMIT, SEV BURNS, ULCERA TION - MOUTH, THROAT, STOMACH &
MAY BE FATAL. CHRONIC: DAMAGE TO LUNGS, TEETH. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: TARGET ORGANS: EYES, SKIN, MUCOUS
MEMBRANES, RESPIRATORY SYSTEM, LUNGS, TEETH, GI TRACT.
Medical Cond Aggravated by Exposure:DAMAGED SKIN, EYE DISORDERS,
CARDIOPULMONARY DISEASE, LUNG DISEASE.

First Aid:INGEST:CALL MD. DO NOT INDUCE VOMITING. IF CONSCIOUS, GIVE
WATER, MILK, OR MILK OF MAGNESIA. INHAL: REMOVE TO FRESH AIR. IF
NOT BREATHING, GIVE ARTIFICIAL RESP. IF BREATHING IS DIFFICULT,
GIVE O*2. SK IN: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN
WHILE REMOVING CONTAMINATED CLOTHING & SHOES. WASH CLTHG BEFORE
RE-USE. EYE: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN.

Flash Point Method:CC
Extinguishing Media:USE WATER SPRAY.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. MOVE EXPOS CNTNRS FROM FIRE AREA IF IT CAN BE DONE W/OUT RISK.
USE WATER TO KEEP FIRE EXPOS (SUPP DATA)
Unusual Fire/Explosion Hazard:STRONG OXIDIZER. CONT W/OTHER MATL MAY
CAUSE FIRE. REACTS W/MOST METALS TO PRODUCE HYDROGEN GAS, WHICH CAN
FORM AN EXPLOSIVE MIX W/AIR. A VIOLENT (SUPP DATA)

Spill Release Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT CLTHG.
STOP LEAK IF YOU CAN DO SO W/OUT RISK. VENT AREA. NEUT SPILL W/SODA
ASH/LIME. W/CLEAN SHOVEL, CAREFULLY PLACE MATL INTO CLEAN, DRY
CNTNR & COVER; REMOVE FROM AREA. FLUSH SPILL AREA W/WATER. (SUPP
DATA)
Neutralizing Agent:SODA ASH OR LIME; J.T. BAKER NEUTRASORB OR TEAM 'LOW
NA+' ACID NEUTRALIZERS.

Handling and Storage Precautions:KEEP CNTNR TIGHTLY CLSD. STORE
SEPARATELY & AWAY FROM FLAMM & COMBUST MATLS. ISOLATE FROM
INCOMPATIBLE MATLS. KEEP PROD OUT OF LIGHT.
Other Precautions:DO NOT GET IN EYES, ON SKIN, ON CLOTHING. DO NOT
BREATHE VAPOR. USE WITH ADEQUATE VENTILATION. MAY BE FATAL IF
SWALLOWED OR INHALED & CAUSE DELAYED LUNG INJURY. STRONG OXIDIZER.
KEEP OUT OF REACH OF C HILDREN.

Respiratory Protection:NIOSH/MSHA APPROVED RESP PROT REQD IF AIRBORNE
CONCENTRATION EXCEEDS TLV. AT CONCENTRATIONS UP TO 100 PPM, A
NIOSH/MSHA APPROVED CHEM CARTRIDGE RESP W/ACID CARTRIDGE IS RECD.
ABOVE THIS LEVEL, A NIOSH /MSHA APPROVED SCBA IS ADVISED.
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS. VENT HOOD.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEM WORK GOG & FULL LGTH FSHLD .
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT, LAB COAT & APRON.
EMERGENCY EYEWASH AND DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. TAKE OFF
IMMEDIATELY ALL CONTAMINATED CLOTHING.
Supplemental Safety and Health
FIRE FIGHT PROC:CNTNRS COOL. DO NOT GET WATER INSIDE CNTNRS. EXPLO
HAZ:EXOTHERMIC REACTION OCCURS W/WATER. SUFFICIENT HEAT MAY BE
PRODUCED TO IGNITE COMBUST MATLS. MATLS TO AVOID: METALS/POWDERED
META LS/CARBIDES/AMMONIUM HYDROXIDE/WATER/ALCOHOLS. PH:1 (0.1M
SOLUTION). SPILL PROC:KEEP COMBUST (WOOD, PAPER, (ING 3)

HCC:C1
Boiling Pt:B.P. Text:249F,121C
Melt/Freeze Pt:M.P/F.P Text:-43F,-42C
Vapor Pres:9 @ 20C
Spec Gravity:1.41 (H*2O=1)
pH:SUPDAT
Solubility in Water:COMPLETE (100%)
Appearance and Odor:CLEAR, COLORLESS LIQUID; SUFFOCATING ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG BASES, CARBONATES, SULFIDES, CYANIDES, COMBUST MATLS, ORG MATLS,
STRONG REDUCING AGETNS, MOST COMMON (SUPP DATA)
Stability Condition to Avoid:HEAT, LIGHT, MOISTURE.
Hazardous Decomposition Products:OXIDES OF NITROGEN, HYDROGEN.

Waste Disposal Methods:DISPOSE I/A/W ALL APPLICABLE FEDERAL, STATE AND
LOCAL ENVIRONMENTAL REGULATIONS. EPA WASTE #D001, D002 (IGNITABLE,
CORROSIVE WASTE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.